996 Engine cuts out without warning

996, 997 and 991 discussion area

Moderator: Moderators

Post Reply
village eejit
Posts: 347
Joined: Wed Nov 07, 2007 11:43 am
TIPEC membership: 4941
Location: Banbury

996 Engine cuts out without warning

Post by village eejit »

Just thought I would share recent scary experiences with my 1998 996 C2 in case anyone else finds themselves in the same position.

The problem started with a refusal on a couple of occasions of the engine to restart after a run. When left for half an hour or so, it would fire up perfectly.

Things then developed into the engine stopping without any warning while doing 60 mph then refusing to restart for an hour while stuck at the road side (fortunately on a straight stretch, but finger biting none the less).

Doing a fair bit of research of the internet resulted in going round in circles with suggestions of fuel pump or relay problems until stumbling on reports of failing crank position sensors causing the exact symptoms my car was experiencing on other cars mainly in The States. Some of these guys had a fair amount of their money wasted by specialists in guessing which parts were causing the problem until eventually the crank position sensor was changed and in almost all cases the problem was fixed.

Had mine changed today and ran the car for over an hour with no problems. I also tested the old sensor by measuring the resistance between pins 1 and 2, then heated the sensor up with a heat gun. Resistance starts at around 800 ohms when at room temp, but goes mental after a few seconds of heat. Once cooled down, the resistance is stable again.

So if you find yourself in the same predicament, a new Bosch sensor cost about £70 from Design 911 http://www.design911.co.uk/fu/pt259_135 ... e-Sensors/ and about an hour to fit after you take off the rear left wheel http://www.pelicanparts.com/techarticle ... ensors.htm.
Steve

986 Boxster S
F355 Challenge Evocation
F355 Spider Evocation
Audi A4 Avant 2.0TDI S-Line
Sean Smallman
Site Admin
Site Admin
Posts: 5518
Joined: Thu Jan 01, 1970 1:00 am
TIPEC membership: 911
Location: Rochester, Kent

Re: 996 Engine cuts out without warning

Post by Sean Smallman »

Thanks for the info, glad you got it sorted :)
Kent & South East London R.O

Join the Club

Silver 1989 911 Speedster
Midnight Blue 2004 996 C4S Cab
Tahoe Blue 1990 964 C2
Zenith Blue 1998 BoxsterSold
Guards Red 1992 944 S2 Cab gone but not forgotten
Mediterranean Blue BMW 530e
village eejit
Posts: 347
Joined: Wed Nov 07, 2007 11:43 am
TIPEC membership: 4941
Location: Banbury

Re: 996 Engine cuts out without warning

Post by village eejit »

A bit more info for clarity:

If you want to go to an OPC for this, the Porsche part number for the crank position sensor aka impulse sender is 986 606 112 02 and will cost about £150.

Don't get confused between this sensor and the camshaft position sensor. Most internet searches for the crank sensor give many results for the camshaft sensor, but as the name suggests, they are completely different sensors.
Steve

986 Boxster S
F355 Challenge Evocation
F355 Spider Evocation
Audi A4 Avant 2.0TDI S-Line
Post Reply