Porsche Enthusiasts Club Forum http://forums.tipec.net/ |
|
Rear Hatch Boot Seal http://forums.tipec.net/viewtopic.php?f=25&t=23331 |
Page 1 of 1 |
Author: | omaltby [ Sun Apr 22, 2018 8:56 pm ] |
Post subject: | Rear Hatch Boot Seal |
Hi all, I purchased a rear hatch boot seal for my 944 from the Porscheshop.co.uk. I've fitted the new seal but there is about 5cm overlap (i.e. it is too long) - is it normal to have to trim it to length? I think I may be able to reduce it by a few mm by compressing the seal but not 5cm worth! Just wanted to check I'm not being a wally before I start cutting it. Cheers, Oliver |
Author: | 996driver [ Sun Apr 22, 2018 9:42 pm ] |
Post subject: | Re: Rear Hatch Boot Seal |
I found exactly the same with the one I bought so you're not alone! The one I got was a sealed circle, I needed to cut it to avoid removing the hatch supports but then found it was too long. I've not yet cut the excess off but before I do I was going to go round the edge with a rubber mallet to make sure that it's fully fitted all way round. |
Author: | kongsodoken [ Sun Apr 22, 2018 10:05 pm ] |
Post subject: | Re: Rear Hatch Boot Seal |
No don’t cut it Fit the join first at the bottom of the hatch Then fit the 4 corners leaving a equal drape between each corner Work the seal into the corners push don’t stretch Then work each of the 4 sides in the seal will compress |
Author: | Waylander [ Sun Apr 22, 2018 10:15 pm ] |
Post subject: | Re: Rear Hatch Boot Seal |
+1 exactly as ken says fit it |
Author: | scam75 [ Mon Apr 23, 2018 2:39 pm ] |
Post subject: | Re: Rear Hatch Boot Seal |
+2 been there! |
Author: | omaltby [ Tue Apr 24, 2018 6:39 am ] |
Post subject: | Re: Rear Hatch Boot Seal |
Thanks for your replies. I managed to fit the seal without cutting anything. With one now under my belt I think I'd be much quicker next time. Thanks all! |
Author: | HowardB [ Tue Jun 19, 2018 10:53 am ] |
Post subject: | Re: Rear Hatch Boot Seal |
+ 3: just done it this morning. Thanks for the good advice! Should be able to drive down to the Le Mans Classic in a couple of weeks without getting gassed by exhaust fumes! |
Page 1 of 1 | All times are UTC [ DST ] |
Powered by phpBB © 2000, 2002, 2005, 2007 phpBB Group http://www.phpbb.com/ |